- Peters Chemical Company - http://www.peterschemical.com -

MSDS Sheet – Calcium Hydroxide

Posted By admin On 08/16/2006 @ 1:16 pm In | No Comments

MATERIAL SAFETY DATA SHEET

Product Name:Calcium Hydroxide (Hydrated Lime)

EPA Reg. No: N/A

1.PRODUCT IDENTIFICATION

Product Name: Hydrated Lime (Calcium Hydroxide)

UN/MA#: N/A

DOT Hazard Class: N/A

TYPICAL CHEMICAL COMPOSITION

Recommended Exposure Limits

Hazardous Components CAS Number OSHA PEL ACGIH TLV-TWA
Mg/m3 N/A N/A N/A
Mg/m3 N/A N/A N/A
Calcium Hydroxide 305-52-0 5 5 N/A N/A
Magnesium Oxide 1309-48-4 10 (fume) 10 (fume) N/A N/A
Calcium Carbonate 1317-65-3 15 15 N/A N/A
Silica 7831-86-9 80/(%SiO2) 5 N/A N/A

PHYSICAL DATA

Boiling Point: N/A

Melting Point: 1076 F (580 C°)

Vapor Pressure: N/A

Vapor Density: N/A

pH:N/A

Solubility in Water:Negligible

Evaporation Rate: N/A

Appearance and Odor: Soft, white crystalline powder; Odorless

2. FIRE AND EXPLOSION HAZARD DATA

Flash Point: N/A

Flammable Limits: N/A

Fire Extinguishing Media: Considered non-combustible. Use media appropriate for surrounding fire.

Special Fire Fighting Procedures: Fire fighters should wear full protective clothing and self-contained breathing apparatus.

Unusual Fire and Explosion Hazards: Not combustible. Excessive dust generation creates a potential explosion hazard.

3. REACTIVITY DATA

Stability: Stable

Incompatibility: Acids, Chlorinated Phenols + Potassium Nitrate, Moleic Anhydride, Nitroparaffins and Phosphorus.

Hazardous Decomposition Products: None expected

Hazardous Polymerization: Will not occur

Conditions to Avoid: N/A

4. SPILL OR LEAK PROCEDURES

Steps to be taken in case material is released: In case of release to the environment, report spills to the National Response Center 1 -800-424-8802

Suggested Local Action: Contain spill. Prevent large quantities from contacting vegetation or domestic and natural water sources. If material is not contaminated place in appropriate DOT approved containers for disposal.

Waste Disposal Method: (ERA Waste identification #: N/A) If contaminated with other materials, the nature and extent of contamination may require the use of specialized disposal methods. If disposal is necessary, comply with all local, state, and federal regulations. Contact your local EPA office for help.

For Hazardous Waste Regulation: call 1-800-424-9346 – The RCRA Hotline.

5. HEALTH HAZARD DATA

Inhalation: Over exposure may produce irritation of the mucous membranes, nose, throat, coughing and shortness of breath. In addition it may contain small amounts of silica particles less than 5mm in diameter. These silica particles are capable of causing silicosis if inhaled in high enough concentrations over an extended period of time. The principal manifestation of silicosis if difficulty in breathing. This condition can progress to dry cough, shortness of breath on exertion, decreased lung function and pulmonary fibrosis.

Skin Contact: May cause irritation, particular on damp skin. Repeated or prolonged contact could lead to dermatitis. Wash affected area with mild soap and water.

Eye Contact: May cause irritation and conjunctivitis. Flush with large amounts of water for at least 15 minutes, while rolling eyeball and lifting eyelid. Get medical attention.

Ingestion: Give milk, egg whites, or water to�

6. EMERGENCY AND FIRST AID PROCEDURE

Inhalation: Remove from exposure. If breathing is difficult or has stopped, administer artificial respiration or oxygen as indicated. Immediately seek medical aid.

Skin Contact: Wash thoroughly with soap and water. Seek medical aid.

Eye Contact: Flush immediately with large amounts of water, lifting the lower and upper lids occasionally. Seed medical help.

Ingestion: Give 1 -2 large glasses of water or milk. Immediately seek medical aid. Never give liquids to an unconscious person.

Carcinogenicity: Not listed as a carcinogen by NTP, (ARC, or OSHA)

Routes of Entry: Inhalation, Skin and Eye Contact if handled in such a manner that dust is generated.

Effects of Overexposure: As sold, this product is not anticipated to pose an acute or significant health hazard. However, if subjected to dust generating processes, adverse health effects may occur.

Calcium oxide is caustic to living tissue. Overexposure may cause irritation of the eyes, skin, and upper respiratory tract Inflammation of the respiratory tract, ulceration and perforation of the nasal septum, bronchitis and pneumonia have also bee attributed to inhalation of calcium oxide dust. Eye contact may cause conjunctivitis, corneal ulceration. Skin contact may cause skin inflammation and ulceration.

Medical Conditions Aggravated by Exposure: Chronic disease and disorders of the respiratory system and skin.

7.SPECIAL PROTECTION INFORMATION

Respiratory: Respiratory protection approved by NIOSH/MSHA for protection against dust should be used to avoid inhalation. Appropriate respiration selection depends on the type and magnitude of exposure.

Skin: Clean, body-covering clothing should be worn to prevent irritation in situation where direct contact with product may occur or dust levels are excessive.

Eyes: Employees should be required to wear chemical safety splash goggles in situations where direct contact with the product may result in eye injury.

Ventilation: Local exhaust ventilation should be used to control worker exposure to below recommended Permissible Exposure Levels (PEL).

Other Protective Equipment: Emergency eye wash stations and deluge safety showers should be available in the work areas.

8. SPECIAL PRECAUTIONS

Precaution to be taken in handling and storage: Store in a cool, dry location. Keep out of reach of children and pets.

THIS INFORMATION IS TAKEN FROM SOURCES OR BASED UPON DATE BELIEVED TO BE RELIABLE; HOWEVER, PETERS CHEMICAL COMPANY, MAKES NO WARRANTY AS TO THE ABSOLUTE CORRECTNESS OR SUFFICIENCY OF ANY OF THE FOREGOING OR THAT ADDITIONAL OR OTHER MEASURES MAY NOT BE REQUIRED UNDER PARTICULAR CONDITIONS.

THIS DOCUMENT HAS BEEN PREPARED SOLELY FOR THE INTENT OF COMPLIANCE WITH THE PROVISIONS OF SUBPART 2 OF PART ’1910 OF TITLE 29 OF THE CODE OF FEDERAL REGULATION, PARAGRAPH 1910.1200 AND CHAPTER 307 OR PART XIII OF THE PENNSYLVANIA WORKER AND COMMUNITY RIGHT TO KNOW ACT, SECTION 17 OF (P.L 734, NO. 159K35 P.S. &7317).


Article printed from Peters Chemical Company: http://www.peterschemical.com

URL to article: http://www.peterschemical.com/calcium-hydroxide/msds-sheet-calcium-hydroxide/